Journal of Dairy Science (Oct 2023)
A meta-analysis of the effects of colostrum heat treatment on colostral viscosity, immunoglobulin G concentration, and the transfer of passive immunity in newborn dairy calves
Abstract
ABSTRACT: Newborn ruminants depend on colostrum intake immediately after birth to obtain immunoglobulins for effective transfer of passive immunity (TPI). As colostrum may also be a vehicle of infectious agents, heat treatment of raw colostrum is a practice aimed at eliminating or reducing its pathogen load. Despite the usefulness of heat treatment in preventing the transmission of infectious colostrum-borne diseases, heat treatment of colostrum may have some side effects. A systematic review and meta-analysis were conducted to summarize the effects of colostrum heat treatment on colostral viscosity and IgG concentration, and serum IgG concentration as a proxy for TPI in newborn calves fed raw versus heat-treated colostrum. Moderators were studied to identify sources of heterogeneity. Literature databases were searched for peer-reviewed articles published between 1946 and 2022. A Master of Science thesis was also included. Five, 21, and 19 original publications were quantitatively evaluated in 3 separate meta-analyses, based on predefined selection criteria. Two-level and 3-level random-effects meta-analysis revealed a significant overall effect of heat treatment on colostral viscosity and IgG concentration, and serum IgG concentration in newborns. Heat-treated colostrum had significantly higher viscosity (21.0 cP, 95% CI: 3.8 to 38.2) and lower IgG concentration (−7.4 g/L, 95% CI: −11.1 to −3.7) compared with raw colostrum. Overall, newborn calves fed heat-treated colostrum had higher serum IgG concentrations (2.8 g/L, 95% CI: 1.4 to 4.0) 24–48 h after birth than those fed with raw colostrum. Particularly, this positive effect on the serum IgG concentrations was seen when colostrum was heat-treated at ≤60°C (2.9 g/L, 95% CI: 0.9 to 4.2) and when the standard low-temperature low-time (LTLT) method was used for heat treatment (2.6 g/L, 95% CI: 0.1 to 5.1). Colostrum treated at >60–63.5°C tended to have higher viscosity (275.6 cP, 95% CI: −37.9 to 589.3) and had lower IgG concentration (−21.7 g/L, 95% CI: −27.3 to −16.1). Calves fed colostrum treated at this temperature range had significantly lower serum IgG (−4.2 g/L, 95% CI: −7.9 to −0.4) compared with those fed raw colostrum. Heat treatment of colostrum at 72–76°C was not associated with a significant increase in colostral viscosity (6.3 cP, 95% CI: −324.3 to 336.9) nor a reduction in IgG colostral concentration (−13.1 g/L, 95% CI: −26.5 to 0.2), but calves fed colostrum treated at this temperature range had a significant reduction in serum IgG (−11.3 g/L, 95% CI: −17.1 to −5.4). Feeding newborn calves with colostrum heat-treated at ≤60°C by the standard LTLT method, particularly within 2 h after birth, resulted in increased serum IgG concentration at 24–48 h of age. Importantly, delaying feeding of heat-treated colostrum to newborns beyond 2 h of age resulted in no significant difference in IgG serum levels compared with feeding raw colostrum, highlighting the importance of early administration of heat-treated colostrum to favor TPI. On-farm colostrum heat treating should achieve an equilibrium between pathogen elimination and the preservation of colostral immunoglobulins while minimizing undesired increases in viscosity. The beneficial effects of colostrum heat treatment on TPI can be negligible if colostrum feeding is not performed within 2 h after birth.
