Poultry Science (Jun 2024)
Carotenoid content and deposition efficiency in yolks of laying hens fed with dent corn hybrids differing in grain hardness and processing
Abstract
ABSTRACT: Yolk carotenoid profile reflects the hen diet when corn grain is the only source of carotenoids, but corn origin and processing may affect carotenoid utilization. In the present study, 2 commercial dent corn hybrids differing in grain hardness (soft- and hard-type) were dried at low (40°C) and high (85°C) temperature and ground through a 5- and 9-mm sieve to investigate their effects on carotenoid bioavailability in laying hens. With 3 hens per cage, 168 Lohmann Brown laying hens were allocated to 8 dietary treatments (2 hybrids × 2 drying temperatures × 2 grinding sieves) in a completely randomized design (8 treatments × 7 cages). The trial lasted 8 wk, during which eggs were collected for analysis every 3 d until carotenoid content stabilized, and then once a week until the end of the experiment. The carotenoid profile of the experimental diets and yolks was analyzed using an HPLC method and deposition efficiency was calculated based on carotenoid contents, yolk weight, egg production and diet intake. The deposition efficiency for lutein, zeaxanthin, α- and β-cryptoxanthin, and β-carotene averaged 27.37, 18.67, 6.29, 3,32, and 0.94%, respectively. As expected, the tested hybrids highly affected the carotenoid content in egg yolk due to their differences in carotenoid profile. Interestingly, hard- and soft-type hybrids differed in the deposition efficiency for all individual carotenoids but not for the total carotenoids. High grain drying temperature tended to increase the bioavailability of lutein and zeaxanthin in both hybrids. For the hard-type hybrid, the content of β-carotene in egg yolk was higher when grains were dried at a high temperature, while the opposite response was found in the soft-type hybrid. The effect of grinding sieve size was important for the zeaxanthin bioavailability in the soft-type hybrid only. In conclusion, our findings showed that corn hybrid had a primary influence on the carotenoid content in the yolks of laying hens, but grain processing may change the bioavailability of carotenoids.
