Development and validation of reliable astaxanthin quantification from natural sources

Abstract

Astaxanthin derived from natural sources occurs in the form of various esters and stereomers, which complicates its quantitative and qualitative analysis. To simplify and standardize astaxanthin measurement with high precision, an enzymolysis-based astaxanthin quantification method was developed to hydrolyze astaxanthin esters and determine free astaxanthin in all its diastereomeric forms. Astaxanthin standards and differently processed Haematococcus pluvialis biomass were investigated. Linear correlation of standards of all-E-astaxanthin was observed in a measurement range between extract concentrations of 1.0 μg/mL and 11.2 μg/mL with a coefficient of variation below 5%. The diastereomers 9Z-, and 13Z-astaxanthin, and two di-Z-forms were detected. In contrast to the measurement of standards, the observed measurement range was extended to 30 μg/mL in extracts from H. pluvialis. The nature of the sample had to be taken into account for measurement, as cell, respectively, sample composition altered the optimal concentration for astaxanthin determination. The measurement precision of all-E-astaxanthin quantification in dried H. pluvialis biomass (1.2–1.8 mg dried biomass per sample) was calculated with a coefficient of variation of maximum 1.1%, whereas it was below 10% regarding the diastereomers. Complete enzymolysis was performed with 1.0 to 2.0 units of cholesterol esterase in the presence of various solvents with up to 2.0 mg biomass (dry weight). The method was compared with other astaxanthin determination approaches in which astaxanthin is converted to acetone in a further step before measurement. The developed method resulted in a higher total astaxanthin recovery but lower selectivity of the diastereomers. The reliability of photometric astaxanthin estimations was assessed by comparing them with the developed chromatographic method. At later stages in the cell cycle of H. pluvialis, all methods yielded similar results (down to 0.1% deviation), but photometry lost precision at earlier stages (up to 31.5% deviation). To optimize sample storage, the shelf life of astaxanthin-containing samples was investigated. Temperatures below -20°C, excluding oxygen, and storing intact H. pluvialis cells instead of dried or disrupted biomass reduced astaxanthin degradation.