Investigating use of chlorine dioxide for pre-treatment of raw water from polluted sources at Morton Jaffray Water Treatment Works, Harare, Zimbabwe

Abstract

Raw water quality deterioration has affected capabilities of Conventional Water Treatment Processes (CWTP) in many countries. CWTP used at Morton Jaffray Water Treatment Works (MJWTW) in Harare have proven ineffective due to pollution. The study investigated the use of chlorine dioxide (ClO2) as an alternative pre-treatment chemical. Its effectiveness was compared to that of calcium hypochlorite (Ca(CIO)2) used at MJWTW. Grab raw water samples from MJWTW were collected between January and March 2020 and pre-treated with ClO2 and Ca(CIO)2 followed by jar tests with alum to determine pre-treatment effectiveness. Parameters analyzed included electrical conductivity (EC), total dissolved solids (TDS), total solids (TS), turbidity, chemical oxygen demand (COD), pH and total algae counts (TAC). The raw water had mean TDS (264 mg/L), TS (440 mg/L), turbidity (7.1 NTU), COD (85 mg/L), pH (7.9) and TAC (28.4 × 106 cells/mL). The optimum alum dosage without pre-oxidation was 80 mg/L. Pre-oxidation with 0.075 mg/L ClO2 reduced alum dosage to 60 mg/L. This ClO2 dosage was compared to a Ca(CIO)2 dosage of the same concentration and strength at 5 and 15-minutes contact time before alum dosage at 60 mg/L. The treated water quality parameter levels proved better performance for ClO2 compared to calcium hypochlorite. HIGHLIGHTS Raw water quality deterioration in Lake Chivero has complicated treatment and treatment costs.; Chemicals currently used have become ineffective including calcium hypochlorite, which creates risk of formation of carcinogenic compounds.; Chlorine dioxide was considered an an alternative as it has been used widely elsewhere, enhances coagulation compared to calcium hypochlorite, and thus is likely to be economic.;

Keywords

• calcium hypochlorite
• chlorine dioxide
• morton jaffray water treatment works
• pre-treatment
• raw water
• water quality