Automated Mobile Hot Mist Generator: A Quest for Effectiveness in Fruit Horticulture

Dmitriy Khort; Alexey Kutyrev; Nikolay Kiktev; Taras Hutsol; Szymon Glowacki; Maciej Kuboń; Tomasz Nurek; Anatolii Rud; Zofia Gródek-Szostak

doi:10.3390/s22093164

Sensors (Apr 2022)

Automated Mobile Hot Mist Generator: A Quest for Effectiveness in Fruit Horticulture

Dmitriy Khort,
Alexey Kutyrev,
Nikolay Kiktev,
Taras Hutsol,
Szymon Glowacki,
Maciej Kuboń,
Tomasz Nurek,
Anatolii Rud,
Zofia Gródek-Szostak

Affiliations

Dmitriy Khort: Department of Technologies and Machines for Horticulture, Viticulture and Nursery, Federal Scientific Agroengineering Center VIM, 1-st Institutsky Proezd, 5, 109428 Moscow, Russia
Alexey Kutyrev: Department of Technologies and Machines for Horticulture, Viticulture and Nursery, Federal Scientific Agroengineering Center VIM, 1-st Institutsky Proezd, 5, 109428 Moscow, Russia
Nikolay Kiktev: Department of Intelligent Technologies, Taras Shevchenko National University of Kyiv, Volodymyrs’ka Str., 64/13, 01601 Kyiv, Ukraine
Taras Hutsol: Department of Mechanics and Agroecosystems Engineering, Polissia National University, Stary Boulevard, 7, 10008 Zhytomyr, Ukraine
Szymon Glowacki: Department of Fundamentals of Engineering and Power Engineering, Institute of Mechanical Engineering, Warsaw University of Life Sciences (SGGW), 02-787 Warsaw, Poland
Maciej Kuboń: Department of Production Engineering, Logistics and Applied Computer Science, Faculty of Production and Power Engineering, University of Agriculture in Krakow, Balicka 116B, 30-149 Krakow, Poland
Tomasz Nurek: Department of Biosystem Engineering, Institute of Mechanical Engineering, Warsaw University of Life Sciences (SGGW), 02-787 Warsaw, Poland
Anatolii Rud: Faculty of Engineering and Technology, Higher Educational Institution “Podillia State University”, 32316 Kamianets-Podilskyi, Ukraine
Zofia Gródek-Szostak: Department of Economics and Enterprise Organization, Cracow University of Economics, 31-510 Krakow, Poland

DOI: https://doi.org/10.3390/s22093164
Journal volume & issue: Vol. 22, no. 9
p. 3164

Abstract

Read online

The study relates to the use of automated plant protection systems in agriculture. The article presents a proprietary automated mobile platform with an aerosol generator of hot mist. Furthermore, the cause of the loss of a chemical preparation in the spraying of plant protection products on the tree crown was determined in the course of field research. A statistical analysis of the results of experiment was carried out and the effect of droplet size on leaf coating density was determined. The manuscript presents a diagram of the degree of penetration of the working solution as it drops into the crown of the tree, as well as a cross-sectional graph of the permeability of the spray from the projection of the fruit tree crown. The most effective modes of operation of the automated mobile platform for spraying plant protection products with a mist generator aggregate were established. Analysis of the results shows that the device meets the spraying requirements of the procedure for spraying plant protection products. The novelty of this research lies in the optimal modes identified by movement of the developed automated mobile platform and the parameters of plant treatment with protective equipment when using a hot mist generator. The following mode parameters were established: the speed of the automated platform was 3.4 km/h, the distance to the crown of the tree was 1.34 m, and the flow rate of the working fluid was 44.1 L/h. Average fuel consumption was 2.5 L/h. Effective aerosol penetration reduced the amount of working fluid used by up to 50 times.

Published in Sensors

ISSN: 1424-8220 (Online)
Publisher: MDPI AG
Country of publisher: Switzerland
LCC subjects: Technology: Chemical technology
Website: http://www.mdpi.com/journal/sensors

About the journal

Abstract

Keywords